Home › Showroom › Compare Products

Compare Products

Generac 25kW Protector in Ponderay, Idaho
Generac 25kW Protector in Ponderay, Idaho
Previous Next
Generac 25kW Protector
Generac 25kW Protector in Ponderay, Idaho
Generac 25kW Protector in Ponderay, Idaho
Previous Next
Generac 25kW Protector

Specs

General Information

Manufacturer
Generac
Generac
Model
25kW Protector
25kW Protector
Model Code
RG025
RG025
Color
Bisque
Bisque

Engine

Engine Make
Generac
Generac
Fuel Type
Natural gas, Propane vapor
Natural gas, Propane vapor
Oil Capacity

Crankcase - 4 qt. (3.8 l)

Oil pump type - Gear

Oil filter type - Full flow spin-on cartridge

Crankcase - 4 qt. (3.8 l)

Oil pump type - Gear

Oil filter type - Full flow spin-on cartridge

Bore x Stroke
3.05 x 3.13 in. (77.4 x 79.5 mm)
3.05 x 3.13 in. (77.4 x 79.5 mm)
Compression Ratio
11:1
11:1
Alternator

Type - Synchronous

Rotor insulation class - H

Stator insulation class - H

Telephone Interference Factor (TIF) - < 50

Output leads 1-phase - 4 wire

Output leads 3-phase - 6 wire

Bearings - Sealed ball

Coupling - Flexible disc

Excitation system - Direct

Type - Synchronous

Rotor insulation class - H

Stator insulation class - H

Telephone Interference Factor (TIF) - < 50

Output leads 1-phase - 4 wire

Output leads 3-phase - 6 wire

Bearings - Sealed ball

Coupling - Flexible disc

Excitation system - Direct

Displacement
1,500 cc (1.5 l)
1,500 cc (1.5 l)
Fuel Consumption

Exercise cycle (Natural Gas) - 60 ft³ / hr. (1.7 m³ / hr.)

Exercise cycle (Propane) - 0.7 gal. / hr. (2.5 l / h.r) [24 ft³ / hr.]

25% of rated load (Natural Gas) - 220 ft³ / hr. (6.3 m³ / hr.)

25% of rated load (Propane) - 2.9 gal. / hr. (9.1 l / hr.) [88 ft³ / hr.]

50% of rated load (Natural Gas) - 297 ft³ / hr. (8.4 m³ / hr.)

50% of rated load (Propane) - 3.3 gal. / hr. (12.3 l / hr.) [119 ft³ / hr.]

75% of rated load (Natural Gas) - 362 ft³ / hr. (10.3 m³ / hr.)

75% of rated load (Propane) - 4 gal. / hr. (15 l / hr.) [145 ft³ / hr.]

100% of rated load (Natural Gas) - 430 ft³ / hr. (12.2 m³ / hr.)

100% of rated load (Propane) - 4.7 gal. / hr. (17.8 l / hr.) [172 ft³ / hr.]

Exercise cycle (Natural Gas) - 60 ft³ / hr. (1.7 m³ / hr.)

Exercise cycle (Propane) - 0.7 gal. / hr. (2.5 l / h.r) [24 ft³ / hr.]

25% of rated load (Natural Gas) - 220 ft³ / hr. (6.3 m³ / hr.)

25% of rated load (Propane) - 2.9 gal. / hr. (9.1 l / hr.) [88 ft³ / hr.]

50% of rated load (Natural Gas) - 297 ft³ / hr. (8.4 m³ / hr.)

50% of rated load (Propane) - 3.3 gal. / hr. (12.3 l / hr.) [119 ft³ / hr.]

75% of rated load (Natural Gas) - 362 ft³ / hr. (10.3 m³ / hr.)

75% of rated load (Propane) - 4 gal. / hr. (15 l / hr.) [145 ft³ / hr.]

100% of rated load (Natural Gas) - 430 ft³ / hr. (12.2 m³ / hr.)

100% of rated load (Propane) - 4.7 gal. / hr. (17.8 l / hr.) [172 ft³ / hr.]

Battery

Not included

Charge Alternator - 12 V 15 A

Static charger - 2 A

Recommended - Group 26F, 525 CCA

System voltage - 12 V

Not included

Charge Alternator - 12 V 15 A

Static charger - 2 A

Recommended - Group 26F, 525 CCA

System voltage - 12 V

Cooling

Liquid

Type - Closed

System coolant capacity - 2 gal. (7.6 l)

Water pump - Belt driven

Fan speed - 2,484 rpm

Fan diameter - 17.7 in. (449.6 mm)

Fan mode - Pusher

Liquid

Type - Closed

System coolant capacity - 2 gal. (7.6 l)

Water pump - Belt driven

Fan speed - 2,484 rpm

Fan diameter - 17.7 in. (449.6 mm)

Fan mode - Pusher

Engine Model
In-line
In-line
Engine Type
4 cylinders
4 cylinders

Measurements

Weight
Shipping - 843 lb. (382 kg)
Shipping - 843 lb. (382 kg)
Height
Overall - 38.6 in. (980 mm)
Overall - 38.6 in. (980 mm)
Width
Overall - 30.6 in. (776 mm)
Overall - 30.6 in. (776 mm)
Length
Overall - 62.2 in. (1,580 mm)
Overall - 62.2 in. (1,580 mm)

Operational

Noise Level

Sound output in 59 dB(A) @ 23 ft. (7 m) with generator in exercise mode*

Sound output in 72 dB(A) @ 23 ft. (7 m) with generator operating at normal load*

(*Sound levels are taken from the front of the generator. Sound levels taken from other sides of the generator may be higher depending on installation parameters.)

Sound output in 59 dB(A) @ 23 ft. (7 m) with generator in exercise mode*

Sound output in 72 dB(A) @ 23 ft. (7 m) with generator operating at normal load*

(*Sound levels are taken from the front of the generator. Sound levels taken from other sides of the generator may be higher depending on installation parameters.)

Maximum Temperature

Maximum operation air temperature on radiator - 140 °F (60 °C)

Ambient - 122 °F (50 °C)

Maximum operation air temperature on radiator - 140 °F (60 °C)

Ambient - 122 °F (50 °C)

DC Output

120 / 240 V, 1Ø, 1.0 pf (LPG / NG) - 25 kW, 104 A, 125 CB

120 / 208 V, 3Ø, 0.8 pf (LPG / NG) - 25 kW, 87 A, 100 CB

120 / 240 V, 3Ø, 0.8 pf (LPG / NG) - 25 kW, 75 A, 90 CB

120 / 240 V, 1Ø, 1.0 pf (LPG / NG) - 25 kW, 104 A, 125 CB

120 / 208 V, 3Ø, 0.8 pf (LPG / NG) - 25 kW, 87 A, 100 CB

120 / 240 V, 3Ø, 0.8 pf (LPG / NG) - 25 kW, 75 A, 90 CB

DC Voltage

Regulation type - Electronic

Regulation sensing - Single phase

Regulation - ± 1%

Regulation type - Electronic

Regulation sensing - Single phase

Regulation - ± 1%

Instrumentation
2 line LCD multilingual digital Evolution™ controller (English / Spanish / French / Portuguese) with external viewing window
2 line LCD multilingual digital Evolution™ controller (English / Spanish / French / Portuguese) with external viewing window

Other

Warranty
5 year limited
5 year limited

Features

Enclosure

  • ALUMINUM WEATHER PROTECTIVE ENCLOSURE: Ensures protection against mother nature. Electrostatically applied textured epoxy paint for added durability.
  • ENCLOSED CRITICAL GRADE MUFFLER: Quiet, critical grade muffler is mounted inside the unit to prevent injuries.
  • SMALL, COMPACT, ATTRACTIVE: Makes for an easy, eye appealing installation.
  • SAE: Sound attenuated enclosure ensures quiet operation.

Features

  • The best liquid cooled engine packs more power into a smaller footprint - ideal when space is a premium. The neutral styling, color and small footprint fits unobtrusively into landscaping. Clean burning, continuous fuel choice of natural gas to LP.
  • TRUE POWER™ TECHNOLOGY: Delivers best-in class power quality with less than 5% total harmonic distortion (THD) for clean, smooth operation of sensitive electronics and appliances.
  • EVOLUTION™ CONTROLLER: A cutting-edge, intuitive control. The Evolution controller features a multilingual, two-line LCD text display with color-coded, backlit buttons. It has received upgrades, including USB flash capability, smart battery charging, voltage adjustment, and backlit membrane pad-style buttons.
  • 5-YEAR LIMITED WARRANTY WITH EXTENDED WARRANTY OPTIONS AVAILABLE: We are proud of our innovative product design, high quality and first-class reliability so we stand behind them with a strong 5, 7 or 10-year limited warranty.
  • CAN BE INSTALLED JUST 18" FROM A STRUCTURE: Capability to be installed 18 inches away from a structure, ideal for areas with tight lot lines. Generac is the only manufacturer of standby generators to have 18” offset on most of its residential lineup.
  • TOUGH, DURABLE All-ALUMINUM ENCLOSURES: Our RhinoCoat™ powder-coated finish helps make corrosion-resistant aluminum perfect for all weather conditions.
  • QUIET-TEST™: All backup generators run a weekly test to ensure the system is running properly. Thanks to Quiet-Test, your Protector Series home generator runs its self-test at a lower, quieter RPM, which can be programmed to run weekly, bi-weekly, or monthly.
  • MOBILE LINK™ CONNECTIVITY: Mobile Link™ Connectivity allows you to monitor the status of your generator from anywhere in the world using a smartphone, tablet or PC. Easily access information such as the current operating status and the generator's maintenance schedule.
  • ADDITIONAL FEATURES: Improved stub ups and electrical connection access decrease installation costs. All connections are dual conductor rated, and the implementation of quick connects for the control wires, completely eliminates the need for crimping or lugging.Improved customer connection access, which decreases installation costs.
  • INNOVATIVE DESIGN & PROTOTYPE TESTING: are key components of GENERAC’S success in “IMPROVING POWER BY DESIGN.” But it doesn’t stop there. Total commitment to component testing, reliability testing, environmental testing, destruction and life testing, plus testing to applicable CSA, NEMA, EGSA, and other standards, allows you to choose GENERAC POWER SYSTEMS with the confidence that these systems will provide superior performance.
  • TEST CRITERIA: Prototype tested, NEMA MG1-22 evaluation, System torsional tested, Motor starting ability.
  • SOLID-STATE, FREQUENCY COMPENSATED VOLTAGE REGULATION: This state-of-the-art power maximizing regulation system is standard on all Generac models. It provides optimized FASTRESPONSE to changing load conditions and MAXIMUM MOTORSTARTING CAPABILITY by electronically torque-matching the surge loads to the engine. Digital voltage regulation at ±1%.
  • SINGLE SOURCE SERVICE RESPONSE: From Generac’s extensive dealer network provides parts and service know-how for the entire unit, from the engine to the smallest electronic component.
  • GENERAC TRANFER SWITCHES.: Long life and reliability are synonymous with GENERAC POWER SYSTEMS. One reason for this confidence is the GENERAC product line is offered with its own transfer systems and controls for total system compatibility.
  • Intake air system - Naturally aspirated
  • Lifter type - Hydraulic
  • Carburetor - Down draft
  • Secondary fuel regulator - Standard
  • Fuel shut off solenoid - Standard
  • LP / NG fuel pressure - 5 - 14 in. water column ( 9 - 26 mm HG)
  • Governor type - Electronic
  • Governor frequency regulation - Isochronous
  • Governor steady state regulation - ± 0.25%
  • Air flow (inlet air including alternator and combustion air - 2,490 cfm (70.5 cmm)
  • Heat rejection to coolant - 112,000 BTU / hr. (118.2 MJ / hr)
  • Flow at rated power - 62 cfm (1.8 cmm)
  • Exhaust flow at rated output - 203 cfm (5.7 cmm)
  • Exhaust temperature at muffler outlet - 1,100 °C (593 °F)
  • Rated synchronous - 3,600 rpm
  • Temperature deration - 3% for every 10 °C above 25 °C or 1.65% for every 10 °F above 77 °F
  • Altitude deration - 1% for every 100 m above 183 m or 3% for every 1,000 ft. above 600 ft.
  • Two-line plain text LCD display - Simple user interface for ease of operation.
  • Auto mode switch - Automatic start on utility failure. 7 day exerciser.
  • Off mode switch - Stops unit. Power is removed. Control and charger still operate.
  • Manual mode switch - Start with starter control, unit stays on. If utility fails, transfer to load takes place.
  • Programmable start delay between 10 - 30 seconds - 10 sec standard
  • Engine start sequence - cyclic cranking - 16 sec on, 7 rest (90 sec maximum duration)
  • Engine warm-up - 5 sec
  • Engine cool-down - 1 min
  • Starter lock-out - Starter cannot re-engage until 5 sec after engine has stopped.
  • Overspeed shutdown - Standard, 72 Hz
  • Smart battery charger, Automatic voltage regulation with over and under voltage protection, Automatic low oil pressure shutdown, High temperature shutdown, Overcrank protection, Safety fused, Failure to transfer protection, Low battery protection, 50 event run log, Future set capable exerciser, Incorrect wiring protection, Internal fault protection, Common external fault capability, Governor failure protection
  • UV / Ozone resistant hoses
  • UL 2200 Listed
  • Capability to be installed within 18 in. (457mm) of a building.* *Only if located away from doors, windows, fresh air intakes, and unless otherwise directed by local codes.

Generator

  • Revolving field heavy duty generator.
  • Directly connected to the engine.
  • Operating temperature rise 120 °C above a 40 °C ambient.
  • Class H insulation is NEMA rated.
  • All models fully prototyped tested.

Remote Monitoring

  • ABILITY TO VIEW GENERATOR STATUS: Monitor generator with a smartphone, tablet, or computer at any time via the Mobile Link application for complete peace of mind.
  • ABILITY TO VIEW GENERATOR EXERCISE / RUN AND TOTAL HOURS: Review the generator's complete protection profile for exercise hours and total hours.
  • ABILITY TO VIEW GENERATOR MAINTENANCE INFORMATION: Provides maintenance information for the specific model generator when scheduled maintenance is due.
  • MONTHLY REPORT WITH PREVIOUS MONTH’S ACTIVITY: Detailed monthly reports provide historical generator information.
  • ABILITY TO VIEW GENERATOR BATTERY INFORMATION: Built in battery diagnostics displaying current state of the battery.
  • WEATHER INFORMATION: Provides detailed local ambient weather conditions for generator location.

Enclosure

  • ALUMINUM WEATHER PROTECTIVE ENCLOSURE: Ensures protection against mother nature. Electrostatically applied textured epoxy paint for added durability.
  • ENCLOSED CRITICAL GRADE MUFFLER: Quiet, critical grade muffler is mounted inside the unit to prevent injuries.
  • SMALL, COMPACT, ATTRACTIVE: Makes for an easy, eye appealing installation.
  • SAE: Sound attenuated enclosure ensures quiet operation.

Features

  • The best liquid cooled engine packs more power into a smaller footprint - ideal when space is a premium. The neutral styling, color and small footprint fits unobtrusively into landscaping. Clean burning, continuous fuel choice of natural gas to LP.
  • TRUE POWER™ TECHNOLOGY: Delivers best-in class power quality with less than 5% total harmonic distortion (THD) for clean, smooth operation of sensitive electronics and appliances.
  • EVOLUTION™ CONTROLLER: A cutting-edge, intuitive control. The Evolution controller features a multilingual, two-line LCD text display with color-coded, backlit buttons. It has received upgrades, including USB flash capability, smart battery charging, voltage adjustment, and backlit membrane pad-style buttons.
  • 5-YEAR LIMITED WARRANTY WITH EXTENDED WARRANTY OPTIONS AVAILABLE: We are proud of our innovative product design, high quality and first-class reliability so we stand behind them with a strong 5, 7 or 10-year limited warranty.
  • CAN BE INSTALLED JUST 18" FROM A STRUCTURE: Capability to be installed 18 inches away from a structure, ideal for areas with tight lot lines. Generac is the only manufacturer of standby generators to have 18” offset on most of its residential lineup.
  • TOUGH, DURABLE All-ALUMINUM ENCLOSURES: Our RhinoCoat™ powder-coated finish helps make corrosion-resistant aluminum perfect for all weather conditions.
  • QUIET-TEST™: All backup generators run a weekly test to ensure the system is running properly. Thanks to Quiet-Test, your Protector Series home generator runs its self-test at a lower, quieter RPM, which can be programmed to run weekly, bi-weekly, or monthly.
  • MOBILE LINK™ CONNECTIVITY: Mobile Link™ Connectivity allows you to monitor the status of your generator from anywhere in the world using a smartphone, tablet or PC. Easily access information such as the current operating status and the generator's maintenance schedule.
  • ADDITIONAL FEATURES: Improved stub ups and electrical connection access decrease installation costs. All connections are dual conductor rated, and the implementation of quick connects for the control wires, completely eliminates the need for crimping or lugging.Improved customer connection access, which decreases installation costs.
  • INNOVATIVE DESIGN & PROTOTYPE TESTING: are key components of GENERAC’S success in “IMPROVING POWER BY DESIGN.” But it doesn’t stop there. Total commitment to component testing, reliability testing, environmental testing, destruction and life testing, plus testing to applicable CSA, NEMA, EGSA, and other standards, allows you to choose GENERAC POWER SYSTEMS with the confidence that these systems will provide superior performance.
  • TEST CRITERIA: Prototype tested, NEMA MG1-22 evaluation, System torsional tested, Motor starting ability.
  • SOLID-STATE, FREQUENCY COMPENSATED VOLTAGE REGULATION: This state-of-the-art power maximizing regulation system is standard on all Generac models. It provides optimized FASTRESPONSE to changing load conditions and MAXIMUM MOTORSTARTING CAPABILITY by electronically torque-matching the surge loads to the engine. Digital voltage regulation at ±1%.
  • SINGLE SOURCE SERVICE RESPONSE: From Generac’s extensive dealer network provides parts and service know-how for the entire unit, from the engine to the smallest electronic component.
  • GENERAC TRANFER SWITCHES.: Long life and reliability are synonymous with GENERAC POWER SYSTEMS. One reason for this confidence is the GENERAC product line is offered with its own transfer systems and controls for total system compatibility.
  • Intake air system - Naturally aspirated
  • Lifter type - Hydraulic
  • Carburetor - Down draft
  • Secondary fuel regulator - Standard
  • Fuel shut off solenoid - Standard
  • LP / NG fuel pressure - 5 - 14 in. water column ( 9 - 26 mm HG)
  • Governor type - Electronic
  • Governor frequency regulation - Isochronous
  • Governor steady state regulation - ± 0.25%
  • Air flow (inlet air including alternator and combustion air - 2,490 cfm (70.5 cmm)
  • Heat rejection to coolant - 112,000 BTU / hr. (118.2 MJ / hr)
  • Flow at rated power - 62 cfm (1.8 cmm)
  • Exhaust flow at rated output - 203 cfm (5.7 cmm)
  • Exhaust temperature at muffler outlet - 1,100 °C (593 °F)
  • Rated synchronous - 3,600 rpm
  • Temperature deration - 3% for every 10 °C above 25 °C or 1.65% for every 10 °F above 77 °F
  • Altitude deration - 1% for every 100 m above 183 m or 3% for every 1,000 ft. above 600 ft.
  • Two-line plain text LCD display - Simple user interface for ease of operation.
  • Auto mode switch - Automatic start on utility failure. 7 day exerciser.
  • Off mode switch - Stops unit. Power is removed. Control and charger still operate.
  • Manual mode switch - Start with starter control, unit stays on. If utility fails, transfer to load takes place.
  • Programmable start delay between 10 - 30 seconds - 10 sec standard
  • Engine start sequence - cyclic cranking - 16 sec on, 7 rest (90 sec maximum duration)
  • Engine warm-up - 5 sec
  • Engine cool-down - 1 min
  • Starter lock-out - Starter cannot re-engage until 5 sec after engine has stopped.
  • Overspeed shutdown - Standard, 72 Hz
  • Smart battery charger, Automatic voltage regulation with over and under voltage protection, Automatic low oil pressure shutdown, High temperature shutdown, Overcrank protection, Safety fused, Failure to transfer protection, Low battery protection, 50 event run log, Future set capable exerciser, Incorrect wiring protection, Internal fault protection, Common external fault capability, Governor failure protection
  • UV / Ozone resistant hoses
  • UL 2200 Listed
  • Capability to be installed within 18 in. (457mm) of a building.* *Only if located away from doors, windows, fresh air intakes, and unless otherwise directed by local codes.

Generator

  • Revolving field heavy duty generator.
  • Directly connected to the engine.
  • Operating temperature rise 120 °C above a 40 °C ambient.
  • Class H insulation is NEMA rated.
  • All models fully prototyped tested.

Remote Monitoring

  • ABILITY TO VIEW GENERATOR STATUS: Monitor generator with a smartphone, tablet, or computer at any time via the Mobile Link application for complete peace of mind.
  • ABILITY TO VIEW GENERATOR EXERCISE / RUN AND TOTAL HOURS: Review the generator's complete protection profile for exercise hours and total hours.
  • ABILITY TO VIEW GENERATOR MAINTENANCE INFORMATION: Provides maintenance information for the specific model generator when scheduled maintenance is due.
  • MONTHLY REPORT WITH PREVIOUS MONTH’S ACTIVITY: Detailed monthly reports provide historical generator information.
  • ABILITY TO VIEW GENERATOR BATTERY INFORMATION: Built in battery diagnostics displaying current state of the battery.
  • WEATHER INFORMATION: Provides detailed local ambient weather conditions for generator location.